P0401
#1
Retired Senior Admin
Expert Gearhead
Thread Starter
Join Date: May 2006
Location: Sheboygan Wisconsin
Posts: 29,661
Likes: 0
Received 28 Likes
on
24 Posts
P0401
P0401
Description
EGR SYSTEM INSUFFICIENT FLOW
PCM tests Exhaust Gas Recirculation (EGR) valve by
momentarily commanding valve on while monitoring engine MAP. PCM will
illuminate MIL and store DTC P0401 if expected increase is not seen
under certain conditions during deceleration.
Symptoms
You may notice drivability problems such as pinging (knock) when the engine is under load or the vehicle is at higher speeds.
Causes
Description
EGR SYSTEM INSUFFICIENT FLOW
PCM tests Exhaust Gas Recirculation (EGR) valve by
momentarily commanding valve on while monitoring engine MAP. PCM will
illuminate MIL and store DTC P0401 if expected increase is not seen
under certain conditions during deceleration.
You may notice drivability problems such as pinging (knock) when the engine is under load or the vehicle is at higher speeds.
Causes
- The valve is not opening or closing
- There is a blockage in the EGR (tube), most likely carbon buildup
- The EGR valve is faulty
- Damaged or cracked EGR tube causing a vacuum leak
- Remove EGR valve and inspect
- Clean out the EGR valve and/or tubing to remove carbon build up
- Check to make sure EGR plug is clean and tight.
- Check for vacuum leaks
- Replace the EGR valve
Thread
Thread Starter
Forum
Replies
Last Post
jessie_harbin
1992-1999
13
01-28-2006 08:56 PM