Electrical Whether you're trying to change your blinker fluid, a burned out bulb, or your radio and speakers on GM vehicles, look here first.

Ground Buss Corrosion 1992-1999

 
Thread Tools
 
Search this Thread
 
Old 06-25-2012, 10:28 AM
  #1  
Retired



Certified Car Nut
Thread Starter
 
Mike's Avatar
 
Join Date: Jul 2003
Location: Dark Side, AZ
Posts: 17,920
Received 1,780 Likes on 1,304 Posts
Mike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond reputeMike has a reputation beyond repute
Default Ground Buss Corrosion 1992-1999

Many electrical problems such as rear lights not working, power windows/door locks not working and mis-diagnosed fuel pump issues can be traced down to a corroded ground buss.

Here is a visual and brief description on where to locate the ground buss and how to
pull it a part, and clean it.

Take off the trim holding down your carpet next to the drivers seat (there is one in the same location passenger side)
Pull back the carpet.
You will find a large electrical conduit with a 'ground buss' taped to it on the out side.


Very carefully cut the tape and pull the ground buss from the conduit.




Now with a small flat screw driver pop off the cover of the ground bus.
Pull the metal buss out of the connector.




Inspect for corrosion and clean with fine steel wool.
Apply dielectric grease on both sides to protect it from future corrosion.
Also make sure you clean off any corrosion found in/on the wire connectors.

Example of corrosion on the buss:


Example of corrosion on back of wires:


The reason for this corrosion is because over time our inner door moldings shrink and allow water to splash in the interior and the water seeps down on top of these two ground areas.

Personal note: mine was so bad that I ended up going to a junk yard and finding two near perfect ground buses from a newer Bonneville. I also cut enough wires to replace my ground wires going to them.


Originally Posted by jwfirebird
I wanted to post this once i got it figured out because i searched and didnt find anything exactly like it.

on my 98 bonneville sse,

Ive been having an issue with the headlight/brake monitor for a while where the headlight monitor will randomly turn on and off and sometimes if you hit the brakes the headlight one will turn off and the brake monitor light will come on. i tried cleaning and checking all the sockets, all the bulbs work. finally i checked out the infamous driver side ground that gets corroded and this is what i found;


the main ground was corroded and heating up the wire, so i soldered them all together. i also cleaned the grounds two behind the pcm and one behind the battery but i think the bus was the issue
__________________
Retired Administrator
2002 *-10 5.7 V8
2023 Jeep Rubicon Diesel


Last edited by Mike; 07-07-2012 at 07:36 PM. Reason: Fixed images.
Mike is offline  
 
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
iwin12
Everything Electrical & Electronic
2
12-17-2008 06:24 AM
xDRx
Everything Electrical & Electronic
9
07-26-2007 11:07 AM
emceepecks
Everything Electrical & Electronic
13
10-18-2006 03:58 PM



Quick Reply: Ground Buss Corrosion 1992-1999



All times are GMT -4. The time now is 10:15 AM.